销售油气产品及水管防腐系统
所提供的涂层系统应符合要求涂层:底漆层(液体粘合剂)、内层
胶带和外层胶带放置
规格由您选择
抗拉强度大于30 N/ cm
打破值得信赖超过300%
水密性小于0.1
尺寸由您选择
使用防腐保护
颜色黑白
又名内包胶带、冷包胶带
厚度15毫米至35毫米
宽度50、100、150、200、300毫米
长度10 20 25 30 50米
ISO 9001, ISO 14001,OHSMS 18001证书
标准ASTM d1000, AWWA c214
温度10 ~ 60
溶液;颜色:rgb(255,102,0);" >1.产品介绍:
溶液;" >Inner Tape ( Anti corrosion Tape Anticorrosion Tape Anti corrosive Tape for Steel Pipe Anti corrosion Coating ) System Des但:
溶液;" >The T-100 series is Cold Applied Anti-corrosion Tape Coating Systems for the anticorrosion /anti corrosion of underground, underwater, and overhead pipelines. Butyl Rubber Adhesive of Anticorrosion Tape is a key in ground performance characteristic coupled with the low and high density polyethylene backing. This kind of tape can be applied by hand or with a wrapping machine.
溶液;颜色:rgb(255,102,0);" >2.聚乙烯PE胶带及底漆应用:
溶液;" >Rust Removal > Priming> Inner Tape & Outer Tape Wrapping
溶液;" >2.1除锈
溶液;" >
溶液;" >Steel Surface needs treating. Its quality shall reach Sa2 or St3 grade as prescribed in GB8923-88 Pre-paint Steel Surface Rust Grade and Rust-removal Grade, and it shall be dust-free.
溶液;" >2.2启动
溶液;" >Primer shall be stirred well before painting. An even film of primer is painted on the steel surface that is rust-removed completely and dust-free. After the primer dries up (one may feel no sticky). The steel pipe can be wrapping with tape (it usually takes 3 to 5 minutes). The primer dosage usually amounts to 80 to 100g / m2．
溶液;" >2.3内带(防腐带)和外带(保护带)的缠绕
溶液;" >The steel pipe that is painted with primer is wrapping with tape by means of suitable devices or tools as per joint needs, and wraps the inner tape and then wraps the outer tape. Tape tensibility can be 10 to 20 N / cm. The overlapped length between beginning and end of an adhesive tape shall be no less than 1/4 circumference of the steel pipe and the total length of adhesive tape shall be no less than 100mm. each film shall be paralleled, and must not be twisted and rumpled.
溶液;Color: rgb(255,102,0);">3. rgb = "质量有限公司控制QA / QC:
溶液;" >Mechanical Test> Plastic Test> Electric Test> Chemical Analysis> Heat Aging Test
溶液;颜色:rgb(255,102,0);" >4.包装:
溶液;" >Covered Tape by Polyethylene sheet,and then loaded to carton.
